feedback
facebook page
Follow Me on Pinterest
twitter page
google plus page
rss feed

Recalled Product

List of recalls for Blue Bird All American

Search Recalls or Browse by Category
Consumer Products (?)
Food & Health (?)
Vehicles (?)
Home > Recalled Products > Vehicle Recalls > Blue Bird > All American Recalls

Blue Bird All American Recalls

There have been 65 recalls on All American vehicles in recent years. The latest, dated 2017-08-18 and published by the NHTSA on 2017-08-25, was due to a problem with the seats. Approximately 309 vehicles were involved. Since 1991, All American's have experienced approximately 123 recall(s) due to hazards with various components, including the seat belts, equipment, school bus stop arm assembly, equipment adaptive and engine. See a list of recalls for your model year below.

IMPORTANT NOTE: Also check the list of Additional Blue Bird Models to the right. At times, the manufacturer or the NHTSA may use slightly different model names, or group models together by series.

Recalled Blue Bird All American vehicles

Do you work for Blue Bird? Contact us to learn how you can control data, information and ads shown on this page.

Detailed Recall Information for Blue Bird All American

Show Recalls for Model Year:
All
1991
1992
1993
1994
1995
1996
1997
1998
1999
2000
2001
2002
2003
2004
2005
2006
2007
2008
2009
2010
2011
2012
2013
2014
2015
2016
2017
2018
2019
2016-03-25 (Published by NHTSA on 2016-04-19)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2011-2017 All American school buses manufactured from August 20, 2010, through December 16, 2015. Buses with rear side emergency doors have seats over the wheelhouse area whose rear legs may detach from the floor in a crash, resulting in belted occupants traveling forward. As such, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Hazard: If the seat does not allow the occupant to be properly restrained in the event of a crash, they would be at an increased risk of injury.
Remedy: Blue Bird will notify owners, and dealers will replace the rear leg assembly, free of charge. The recall is expected to begin on, or about, April 22, 2016. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's recall number for this campaign is R16YM-SB.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V172000
   
2015-11-04 (Published by NHTSA on 2015-11-21)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2007-2015 All American and Vision and 2007-2011 Micro Bird transit buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured January 1, 2006, to August 25, 2014 by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Hazard: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: Blue Bird will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall is expected to begin November 30, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242, or Ricon Customer Service at 1-800-322-2884.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V731000
   
2015-11-04 (Published by NHTSA on 2015-11-21)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2007-2015 All American, Vision, 2007-2011 Micro Bird, and 2007-2008 Conventional school buses, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured January 1, 2006, to August 25, 2014 by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Hazard: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: Blue Bird will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall is expected to begin November 30, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242, or Ricon Customer Service at 1-800-322-2884.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V730000
   
2015-05-19 (Published by NHTSA on 2015-06-27)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2009-2016 All American rear engine school buses manufactured December 7, 2008, to May 11, 2015, and equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Hazard: If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Remedy: Cummins will notify owners on behalf of Blue Bird, and Cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ECM) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall is expected to begin in June 2015. Owners may contact Blue Bird customer service at 1-478-822-2242 or Cummins Inc. at 1-800-343-7357. Blue Bird's number for this recall is R15YE-NSB.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V294000
   
2015-05-19 (Published by NHTSA on 2015-06-27)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2009-2016 All American rear engine school buses manufactured December 7, 2008, to May 11, 2015, and equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Hazard: If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Remedy: Cummins will notify owners on behalf of Blue Bird, and Cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ECM) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 12, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242 or Cummins Inc. at 1-800-343-7357. Blue Bird's number for this recall is R15YE-SB.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V293000
   
2015-03-10 (Published by NHTSA on 2015-03-24)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2013-2016 All American A3FE, A3RE, T3FE, T3RE, and D3RE school buses manufactured June 28, 2012, to September 25, 2014, and 2013-2016 Vision BBCV school buses manufactured June 9, 2012, to September 30, 2014. Incorrect fasteners may have been used to secure the seat gusset reinforcement to the side wall resulting in the seat belts being improperly anchored. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 210, "Seat Belt Assembly Anchorages."
Hazard: If the seat belts are improperly anchored, there is an increased risk of occupant injury in the event of a crash.
Remedy: Blue Bird will notify owners, and dealers will inspect the the seat gusset reinforcement mounting fasteners, and will install an additional gusset reinforcement bracket, as necessary, free of charge. The recall is expected to begin April 2, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Birds number for this recall is R15YC-SB.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V136000
   
2015-02-03 (Published by NHTSA on 2015-02-16)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2011-2016 All American rear engine school buses manufactured June 5, 2010, to January 13, 2015. In the affected school buses, the exhaust system hangers may fail, possibly causing damage to the Selective Catalytic Reduction (SCR) and the Diesel Particulate Filter (DPF) housings.
Hazard: If all the exhaust hangers were to fail, the housings may fall onto the roadway, creating a road hazard and increasing the risk of a crash.
Remedy: Blue Bird will notify owners, and dealers will install new bolted hanger assemblies and support cables, free of charge. The recall is expected to begin March 6, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R15YB-SB.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V059000
   
2015-02-03 (Published by NHTSA on 2015-02-16)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2011-2016 All American rear engine transit buses manufactured June 5, 2010, to January 13, 2015. In the affected transit buses, the exhaust system hangers may fail, possibly causing damage to the Selective Catalytic Reduction (SCR) and the Diesel Particulate Filter (DPF) housings.
Hazard: If all the exhaust hangers were to fail, the housings may fall onto the roadway, creating a road hazard and increasing the risk of a crash.
Remedy: Blue Bird will notify owners, and dealers will install new bolted hanger assemblies and support cables, free of charge. The recall is expected to begin March 6, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R15YB-NSB.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V060000
   
2014-08-19 (Published by NHTSA on 2014-09-24)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2007-2015 All American and Vision, 2007-2011 Micro Bird, and 2007-2008 Conventional school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Hazard: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Blue Bird will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall is expected to begin during September 2014. Owners may contact Blue Bird customer service at 1-478-822-2242 or Ricon customer service at 1-800-322-2884. Blue Bird's number for this recall is R14XN.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V510000
   
2014-08-19 (Published by NHTSA on 2014-09-24)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2007-2015 All American, 2007-2010 Micro Bird, and 2007-2014 Vision non-school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Hazard: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Blue Bird will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall is expected to begin during September 2014. Owners may contact Blue Bird customer service at 1-478-822-2242 or Ricon customer service at 1-800-322-2884. Blue Bird's number for this recall is R14XN.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V511000
   
2014-07-21 (Published by NHTSA on 2014-07-21)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2013-2014 All American rear engine school buses manufactured July 21, 2011 to April 30, 2014, and equipped with CNG fuel systems and delivered to the following "Cold Weather" states: Colorado, Pennsylvania, Utah, and Wyoming. In the affected vehicles, an O-ring in the pressure relief device for the compressed natural gas (CNG) system may fail at cold temperatures resulting in a natural gas leak.
Hazard: A natural gas leak in the presence of an ignition source could potentially cause a fire or explosion.
Remedy: Blue Bird will notify owners, and dealers will replace the original pressure relief device and o-ring with a new one, free of charge. The recall is expected to begin in September 2014. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XH.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V436000
   
2014-06-10 (Published by NHTSA on 2014-06-10)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain 2012-2015 All American school buses manufactured August 20, 2011, through May 21, 2014. In the affected vehicles, a clamp on the steering shaft may come in contact with the rubber boot at the floor.
Hazard: If the steering shaft clamp comes into contact with the rubber boot, additional effort would be needed to steer the vehicle, increasing the risk of a crash.
Remedy: Blue Bird will notify owners, and dealers will relocate the rubber boot and install a new steering shaft clamp, free of charge. The recall began on July 8, 2014. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XE.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V309000
   
2014-06-09 (Published by NHTSA on 2014-06-09)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain 2012-2015 All American transit buses manufactured September 1, 2011 through May 16, 2014. In the affected vehicles, a clamp on the steering shaft may come in contact with the rubber boot at the floor.
Hazard: If the steering shaft clamp comes into contact with the rubber boot, additional effort would be needed to steer the vehicle, increasing the risk of a crash.
Remedy: Blue Bird will notify owners, and dealers will relocate the rubber boot and install a new steering shaft clamp, free of charge. The recall began on July 8, 2014. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XE.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V306000
   
2014-04-25 (Published by NHTSA on 2014-05-28)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2009-2015 All American rear engine non-school buses manufactured from June 23, 2010, through May 24, 2012, and equipped with certain Cummins Westport Model ISL G compressed natural gas engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
Hazard: The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
Remedy: Cummins and Cummins Westport has notified owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Blue Bird at 1-478-822-2242 or Cummins Inc. at 1-800-343-7357. Blue Bird's number for this recall is R14XB.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V215000
   
2014-03-13 (Published by NHTSA on 2014-04-03)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2014 Vision and All American school buses manufactured January 21, 2013, through February 28, 2013. In the affected vehicles, the joint between the rear wheelhousing and body gusset panel may have partially separated during manufacturing. Thus, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 221, "School Bus Body Joint Strength."
Hazard: A joint separation between the rear wheelhousing and body gusset panel may increase the risk the injury to bus occupants in the event of a crash.
Remedy: Blue Bird will notify owners, and dealers will inspect the joint connections and install a two part adhesive and mechanical fasteners, as necessary, free of charge. The recall is expected to begin on April 11, 2014. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R14XC.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V110000
   
2014-03-04 (Published by NHTSA on 2014-03-12)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2009-2015 All American rear engine school buses manufactured from December 8, 2008, through November 15, 2013, and equipped with certain Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
Hazard: The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
Remedy: Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The manufacturer has not yet provided a notification schedule. Customers may contact Blue Bird at 1-478-822-2242 or Cummins Inc. at 1-800-343-7357. Blue Bird's number for this recall is R14XB.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V083000
   
2013-12-26 (Published by NHTSA on 2014-01-11)
Recall Summary: Blue Bird Corporation is recalling certain 2014-2015 model year All American and Vision school buses manufactured from September 24, 2013, through December 6, 2013. In the affected vehicles, a component within the hydraulic park brake pedal arm may not have been properly heat treated and may fracture causing the parking brake to release without warning.
Hazard: If the park brake pedal arm fractures, the bus may unexpectedly roll increasing the risk of personal injury or a vehicle crash.
Remedy: Blue Bird has notified owners and dealers will install a new parking brake assembly, free of charge. The recall began on December 31, 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R13WT.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V643000
   
2013-11-22 (Published by NHTSA on 2013-12-18)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2014 and 2015 Vision and All American model school buses manufactured August 23, 2013, through November 6, 2013 and equipped with IMMI-brand L9 driver's seat belts. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, preventing the seat belt from unlatching. Thus, this equipment fails to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."
Hazard: If the seat belt buckle stays latched when the button is pressed, there is an increased risk of injury in an emergency, or the seat belt may not properly release in the event of an accident.
Remedy: Blue Bird will notify owners, and dealers will inspect the seat belt buckle, and if necessary, replace the seat belt buckle, free of charge. The recall is expected to begin on December 19, 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's recall number R13WS.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V579000
   
2013-11-22 (Published by NHTSA on 2013-12-18)
Recall Summary: Blue Bird Body Company (Blue Bird) is recalling certain model year 2014 Vision and All American model non-school buses manufactured August 23, 2013, through November 6, 2013 and equipped with IMMI-brand L9 driver's seat belts. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, preventing the seat belt from unlatching. Thus, this equipment fails to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."
Hazard: If the seat belt buckle stays latched when the button is pressed, there is an increased risk of injury in an emergency, or the seat belt may not properly release in the event of an accident.
Remedy: Blue Bird will notify owners, and dealers will inspect the seat belt buckle, and if necessary, replace the seat belt buckle, free of charge. The recall is expected to begin on December 19, 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird recall number R13WS.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V577000
   
2013-11-12 (Published by NHTSA on 2013-12-10)
Recall Summary: Blue Bird Corporation (Blue Bird) is recalling certain model year 2014 All American and Conventional school buses manufactured July 2, 2013, through October 3, 2013 and equipped with front suspension bolts marked with a "ZY" code on the bolt head. Due to a problem in the bolt manufacturing process, the bolts that hold the front suspension may break.
Hazard: A broken suspension bolt would require greater steering input to control the bus, thereby increasing the risk of a crash.
Remedy: Blue Bird will notify owners, and dealers will inspect the front suspension bolts. Any bolts with a "ZY" code will be replaced free of charge. The recall is expected to begin in mid-December 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R13WR.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V543000
   
2013-11-12 (Published by NHTSA on 2013-12-10)
Recall Summary: Blue Bird Corporation (Blue Bird) is recalling certain model year 2014 All American and Conventional Vision non-school buses manufactured July 2, 2013, through October 3, 2013 and equipped with front suspension bolts marked with a "ZY" code on the bolt head. Due to a problem in the bolt manufacturing process, the bolts that hold the front suspension may break.
Hazard: A broken suspension bolt would require greater steering input to control the bus, thereby increasing the risk of a crash.
Remedy: Blue Bird will notify owners, and dealers will inspect the front suspension bolts. Any bolts with a "ZY" code will be replaced free of charge. The recall is expected to begin in mid-December 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R13WR.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V545000
   
2013-08-06 (Published by NHTSA on 2013-08-09)
Recall Summary: Blue Bird Body Company is recalling certain model year 2007-2014 All American and Vision school buses manufactured March 10, 2006, through June 18, 2013; and equipped with optional transit sliding windows. Joint adhesive may not have been applied at the interior and exterior body window panel joints. Without the adhesive, these vehicles fail to conform to the standards of Federal Motor Vehicle Safety Standard (FMVSS) No. 221, "School Bus Body Joint Strength."
Hazard: In the event of a vehicle crash, there is an increased risk that the window panels may separate and fall onto occupants causing injury.
Remedy: Blue Bird will notify owners, and dealers will install additional rivets at the window panel joints, free of charge. The recall is expected to begin by August 30, 2013. Owners may contact Blue Bird at 1-478-825-2021. Blue Bird's recall number is R13WM.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V332000
   
2013-05-15 (Published by NHTSA on 2013-05-24)
Recall Summary: Blue Bird is recalling certain model year 2010 through 2014 All American and Vision model school buses manufactured from August 25, 2009, through March 19, 2013, and equipped with C. E. White Inc. Flip Seats models Quasi Static "QSJ11" (30", 36", 39" and 45"), Student Safety Seat "SSSJ" (30", 36", 39" and 45"), or School Bus Seat "SBJ" (30", 36", 39" and 45").
Hazard: When a Flip Seat is installed in front of another passenger seat, it is possible for the occupant of the rearward passenger seat to insert their toes and/or foot into the lower frame area of the Flip Seat. When a vehicle passenger occupies the Flip Seat, pushing the seat bottom downward to the horizontal position to sit in the seat, the occupant of the rearward seat could suffer a pinch point injury to their toes and/or foot.
Remedy: Blue Bird will notify owners, and dealers will install a safety guard to prevent passengers from placing their toes or feet in the opening on the back of the subject Flip Seats, free of charge. The recall is expected to begin on, or about, June 13, 2013. Owners may contact Blue Bird at 1-478-822-2242 for more information. Blue Bird's number for this campaign is R13WF.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V200000
   
Advertisement

Advertisement

Additional Blue Bird Models

Recalls have also been issued under these model names:

Latest Safety Recalls

Select image for details, including additional styles.

 

Advertisement

Comments

Do you have comments or questions about this recall? Share them here.

Note: The recalling companies may not be monitoring these comments; they should be directed toward the public. Community Guidelines apply.

comments powered by Disqus
Back to Top



Sources may include: National Highway Traffic Safety Administration (NHTSA) and companies involved with this or a related recall.