feedback
facebook page
Follow Me on Pinterest
twitter page
google plus page
rss feed

Recalled Product

List of recalls for Coachmen Rendezvous

Search Recalls or Browse by Category
Consumer Products (?)
Food & Health (?)
Vehicles (?)
Home > Recalled Products > Vehicle Recalls > Coachmen > Rendezvous Recalls

Coachmen Rendezvous Recalls

There have been 2 recalls on Rendezvous vehicles in recent years. The latest was issued on 2009-06-01 due to a problem with the fluid. Approximately 2555 vehicles were involved. Since 2000, Rendezvous's have experienced approximately 7 recall(s) due to hazards with various components, including the recreational vehicle, electrical system. See a list of recalls for your model year below.

IMPORTANT NOTE: Also check the list of Additional Coachmen Models to the right. At times, the manufacturer or the NHTSA may use slightly different model names, or group models together by series.

Recalled Coachmen Rendezvous vehicles

Do you work for Coachmen? Contact us to learn how you can control data, information and ads shown on this page.

Detailed Recall Information for Coachmen Rendezvous

Show Recalls for Model Year:
All
2000
2001
2002
2003
2004
2005
2006
2007
2008
2009
2009-06-01 (Published by NHTSA on 2009-06-01)
Recall Summary: COACHMEN IS RECALLING 2,555 MY 2000-2009 GEORGIE BOY AND COACHMEN RECREATIONAL TRAILERS EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Hazard: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR COACHMEN AT 1-574-266-4030, option 5.
Additional Info: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=09V193000
   
2008-06-24 (Published by NHTSA on 2008-06-24)
Recall Summary: COACHMEN IS RECALLING 37,293 MOTORHOMES AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Hazard: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Remedy: COACHMEN IS WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COACHMEN AT 574-825-5821.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=08V279000
   
2005-03-15 (Published by NHTSA on 2005-03-15)
Recall Summary: ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 101, "CONTROLS AND DISPLAY" AND STANDARD NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." MODELS WITH ACTIA INSTRUMENT CLUSTER, THE INCORRECT SOFTWARE PROGRAMMED INTO THE CLUSTER SUCH THAT CERTAIN WARNINGS ARE NOT DISPLAYED.
Hazard: INCORRECT SOFTWARE MAY NOT HAVE THE ABILITY TO ILLUMINATE WARNING LAMPS INDICATING BRAKE SYSTEM FAILURES. THE STANDARDS REQUIRE DRIVER WARNING WHEN BRAKE FAILURE CODES ARE SET.
Remedy: WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR COACHMEN AT 574-825-5821.
Additional Info: WORKHORSE RECALL NO. 50402-C.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=05V091000
   
2004-10-28 (Published by NHTSA on 2004-10-28)
Recall Summary: ON MOTOR HOME CHASSIS BUILT BY WORKHORSE AND EQUIPPED WITH BOSCH BRAKES, THE PADS CAN DRAG ON THE ROTOR SURFACE DUE TO THE PIN SLIDE.
Hazard: A HANG UP OR LOCK UP MAY CAUSE THE CALIPERS TO OVER HEAT AND NOT ALLOW THE DRIVER TO STOP SAFELY. THIS COULD CAUSE OVERHEATING OF THE BRAKE CALIPERS WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy: WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPAIR THE BRAKE CALIPER. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-294-6773 OR COACHMEN AT 219-825-5821.
Additional Info: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=04V518000
   
2003-10-20 (Published by NHTSA on 2003-10-20)
Recall Summary: ON CERTAIN MOTOR HOMES, TRAVEL TRAILERS, AND FIFTH WHEEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Hazard: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR COACHMEN AT 1-219-825-5821.
Additional Info: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=03V373000
   
2003-04-22 (Published by NHTSA on 2003-04-22)
Recall Summary: ON CERTAIN MOTOR HOMES. THE FRAME EXTRUSION AT THE BASE OF THE KITCHEN SLIDE ROOM, THAT SERVES TO MAINTAIN THE LOCKING MECHANISM FOR THE SLIDE ROOM, MAY BECOME LOOSE FROM THE BODY OF THE VEHICLE. WHEN THIS OCCURS, THE LOCKING MECHANISM IS RENDERED INEFFECTIVE AND THE SLIDE ROOM CAN OPEN UNEXPECTEDLY.
Hazard: SHOULD THIS OCCUR WHILE THE VEHICLE IS IN MOTION, THE POTENTIAL EXISTS FOR A CRASH.
Remedy: DEALERS WILL INSTALL LONGER SELF-TAPPING SCREWS TO ENSURE THE EXTRUSION IS SECURED TO THE STEEL FRAMING. IN ADDITION, "TRAVEL LOCKS" THAT, WHILE IN PLACE, PREVENT THE SLIDE ROOM FROM MOVING OUT UNDER ANY CIRCUMSTANCES WILL BE SUPPLIED WITH ALL UNITS. OWNER NOTIFICATION BEGAN ON APRIL 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-219-825-5821.
Additional Info: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=03V134000
   
2003-02-12 (Published by NHTSA on 2003-02-12)
Recall Summary: CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Hazard: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION BEGAN MARCH 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-219-825-5821.
Additional Info: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=03V040000
   
Advertisement

Advertisement

Additional Coachmen Models

Recalls have also been issued under these model names:

Latest Safety Recalls

Select image for details, including additional styles.

 

Advertisement

Comments

Do you have comments or questions about this recall? Share them here.

Note: The recalling companies may not be monitoring these comments; they should be directed toward the public. Community Guidelines apply.

comments powered by Disqus
Back to Top



Sources may include: National Highway Traffic Safety Administration (NHTSA) and companies involved with this or a related recall.