feedback
facebook page
Follow Me on Pinterest
twitter page
google plus page
rss feed

Recalled Product

List of recalls for Ford Aerostar

Search Recalls or Browse by Category
Consumer Products (?)
Food & Health (?)
Vehicles (?)
Home > Recalled Products > Vehicle Recalls > Ford > Aerostar Recalls

Ford Aerostar Recalls

There have been 0 recalls on Aerostar vehicles in recent years. The latest was issued on 2001-01-02 due to a problem with the cables. Approximately 36500 vehicles were involved. Since 1992, Aerostar's have experienced approximately 4 recall(s) due to hazards with various components, including the transfer case (4-wheel drive), front underhood, switch. See a list of recalls for your model year below.

IMPORTANT NOTE: Also check the list of Additional Ford Models to the right. At times, the manufacturer or the NHTSA may use slightly different model names, or group models together by series.

Recalled Ford Aerostar vehicles

Do you work for Ford? Contact us to learn how you can control data, information and ads shown on this page.

Detailed Recall Information for Ford Aerostar

Show Recalls for Model Year:
All
1992
1993
1994
1995
1996
1997
2001-01-02 (Published by NHTSA on 2001-01-02)
Recall Summary: VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH 3.0L ENGINES. AN ACCELERATOR CABLE WAS KINKED DURING INSTALLATION, CAUSING THE CORE WIRES TO EVENTUALLY FRAY.
Hazard: THIS COULD INCREASE THE FRICTION IN THE CABLE, CAUSING THE THROTTLE TO BE SLOW TO RETURN TO IDLE. THIS CONDITION COULD RESULT IN A STUCK THROTTLE.
Remedy: DEALERS WILL INSTALL A NEW ACCELERATOR CABLE.
Additional Info: OWNER NOTIFICATION BEGAN FEBRUARY 23, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=00V425000
   
1999-04-29 (Published by NHTSA on 1999-04-29)
Recall Summary: VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. (THIS INCLUDES ALL 1992 AWD AEROSTARS NOT PREVIOUSLY INCLUDED IN SAFETY RECALL 97V-204/97S83). THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Hazard: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Additional Info: OWNER NOTIFICATION BEGAN JUNE 17, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=99V094000
   
1999-02-16 (Published by NHTSA on 1999-02-16)
Recall Summary: VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC.
Hazard: HEAT DAMAGE, INCLUDING MELTING OR CHARRING OF THE FUEL PUMP AND SENDER ASSEMBLY WIRE HARNESS AND ASSOCIATED WIRING HARNESSES CAN ALSO RESULT. THE SHORT CIRCUIT COULD ALSO HAVE THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS IN THE FUEL PUMP GROUND CIRCUIT THAT WILL BE INSTALLED AT THE FUEL PUMP INERTIA SHUT-OFF SWITCH.
Additional Info: OWNER NOTIFICATION BEGAN APRIL 7, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=99V028000
   
1999-02-16 (Published by NHTSA on 1999-02-16)
Recall Summary: VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Hazard: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
Additional Info: OWNER NOTIFICATION BEGAN MARCH 19, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACTFORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=99V029000
   
Advertisement

Advertisement

Additional Ford Models

Recalls have also been issued under these model names:
70008000
A9513Aeromax
At9513At9522
BroncoC Max Hybrid
C-maxC-max Energi
Club WagonContour
Crown VictoriaCvpi
E 150E 250
E 350E 350 Allstar
E 350 CutawayE 350 Starlite
E 350 VanE 450
E 450 AllstarE 450 Cutaway
E 550E Series
E-450 Roush PropaneE150
E250E350
E450Econoline
Econoline 350Edge
EscapeEscape Hev
EscortExcursion
ExpeditionExplorer
Explorer Police InterceptExplorer Sport
Explorer Sport TracF 150
F 250F 250 Sd
F 350F 350 Cutaway
F 350 SdF 450
F 450 CutawayF 450 Sd
F 53F 550
F 550 CutawayF 550 Sd
F 59F 650
F 650 SdF 750
F 750 SdF Series
F Super DutyF-350 Super Duty
F-450 Super DutyF-550 Super Duty
F-650 Roush PropaneF-750 Roush Propane
F150F250
F350F450 Classic Traveler
F53F550 Classic Traveler
F59 Roush PropaneF750
FiestaFive Hundred
FlexFocus
Focus ElectricFocus Svt
FordFord Gt
FreestarFreestar Conversion
FreestyleFusion
Fusion EnergiFusion Hybrid
Grand MarquisGT
Heavy DutyL8501
LCFLimo Coach
LouisvilleMountaineer
MPVMpv Bus
MustangMustang Cobra
Mustang Cobra RMustang Gt
NavigatorOdyssey
Odyssey LtOdyssey Mpv
Odyssey XlPolice Interceptor Sedan
Police Interceptor UtilitRanger
Ranger EvSupercrew
TaurusTaurus Police Interceptor
Taurus ShoTaurus X
Terra TransitThunderbird
TransitTransit Connect
Usps Stripped ChassisVAN
Van TerraWindstar

Latest Safety Recalls

Select image for details, including additional styles.

 

Advertisement

Comments

Do you have comments or questions about this recall? Share them here.

Note: The recalling companies may not be monitoring these comments; they should be directed toward the public. Community Guidelines apply.

comments powered by Disqus
Back to Top



Sources may include: National Highway Traffic Safety Administration (NHTSA) and companies involved with this or a related recall.