feedback
facebook page
Follow Me on Pinterest
twitter page
google plus page
rss feed

Recalled Product

List of recalls for Nabi 416

Search Recalls or Browse by Category
Consumer Products (?)
Food & Health (?)
Vehicles (?)

Nabi 416 Recalls

There have been 8 recalls on 416 vehicles in recent years. The latest, dated 2016-01-26 and published by the NHTSA on 2016-02-10, was due to a problem with the seats. Approximately 4848 vehicles were involved. Since 1993, 416's have experienced approximately 10 recall(s) due to hazards with various components, including the automatic transmission, electrical system, visibility, shaft pitman and exhaust system. See a list of recalls for your model year below.

IMPORTANT NOTE: Also check the list of Additional Nabi Models to the right. At times, the manufacturer or the NHTSA may use slightly different model names, or group models together by series.

Recalled Nabi 416 vehicles

Do you work for Nabi? Contact us to learn how you can control data, information and ads shown on this page.

Detailed Recall Information for Nabi 416

Show Recalls for Model Year:
All
1993
1994
1995
1996
2001
2002
2003
2004
2005
2006
2007
2008
2009
2010
2011
2012
2013
2014
2015
2016-01-26 (Published by NHTSA on 2016-02-10)
Recall Summary: New Flyer Industries, Ltd. (New Flyer) is recalling certain model year 2015 New Flyer MD30, 2012 C35LFR, 2010-2011 D35LFR, NABI 35LFW, 2011 D40LFR, 2010-2012 D60LFR and NABI 31LFW, 2010 C40LF, DE35LF, D40LF, DE40LFA, DE60LFA, GE35LFR and GE40LF, 2009 DE60LF and GE40LFR, 2010-2013 C40LFR, DE60LFR, NABI 416 and NABI 60BRT, 2010-2015 XD35, XDE40, NABI 40LFW and 42BRT, 2011-2015 XD40 and XN40, 2013-2015 XD60, XDE60 and XN35, 2010-2014 XDE35, 2013 XE40, 2012-2015 XN60, equipped with certain Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket.
Hazard: If the seatbelt anchorage assembly separates from the J-Bracket, the bus driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: New Flyer will notify owners instructing them to inspect their seats for missing welds. Recaro will supply replacement anchorage brackets and cover the labor to replace them if any welds are missing, free of charge. The recall is expected to begin in February 2016. Owners may contact New Flyer customer service at 1-204-224-6706, or Recaro customer service at 1-800-873-2276. New Flyer's number for this recall is R16-001.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V038000
   
2014-09-23 (Published by NHTSA on 2014-11-07)
Recall Summary: NABI Bus, LLC (NABI) is recalling certain model year 2012 31LFW transit buses manufactured April 28, 2012, to December 16, 2012, and 2008-2013 416 transit buses manufactured October 30, 2008, to February 15, 2014. The affected vehicles may not be equipped with a transmission interlock that prevents the wheelchair lift or ramp from being moved from the stowed position unless the transmission is in neutral. As such, the buses fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems for Motor Vehicles."
Hazard: If the wheelchair lift or ramp can be removed from the stowed position while the transmission is not in neutral, if the service brakes fail to hold the bus, the bus may move unexpectedly, increasing the risk of injury to the wheelchair lift or ramp user.
Remedy: NABI will notify owners, and dealers will install a new electrical program that prevents the lift or ramp from being moved from the stowed position unless the transmission is in neutral, free of charge. The recall began in November 2014. Owners may contact NABI customer service at 1-256-241-1298. NABI's number for this recall is 20146.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V587000
   
2013-04-11 (Published by NHTSA on 2013-04-11)
Recall Summary: North American Bus Industries (NABI) is recalling certain model year 2008-2013 416 and model year 2012 31LFW transit buses manufactured October 30, 2008, through April 3, 2013 and equipped with a four-position rotary defroster switch with ring terminals. The defroster switch may overheat and melt the dash.
Hazard: The overheating of the switch may lead to a fire or distract the driver and increase the risk of an accident.
Remedy: NABI will notify owners and will install relays to reduce the current flow. This will be done free of charge. The recall is expected to begin in April 2013. Owners may contact NABI at 1-256-831-4296. NABI's campaign number is 20133.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V131000
   
2012-09-12 (Published by NHTSA on 2012-09-12)
Recall Summary: North American Bus Industries (NABI) is recalling certain model year 2010 416 and 40LFW transit buses manufactured from January 1, 2010, through November 30, 2010. The emergency release handles on the emergency egress passenger windows may fail, causing the window release mechanism to operate improperly.
Hazard: In the event of an emergency, the windows may fail to open and passengers may be delayed in exiting, increasing the risk of personal injury.
Remedy: NABI will inspect and replace the window release handles, free of charge. The safety recall began on November 9, 2012. Owners may contact NABI at 1-256-831-4296.
Additional Info: NABI's recall campaign number is 20124. Customers may contact the National Highway Traffic Safety Administration's Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153); or go to http://www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=12V444000
   
2012-03-23 (Published by NHTSA on 2012-03-23)
Recall Summary: NORTH AMERICAN BUS INDUSTRIES (NABI) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 416 TRANSIT BUSES MANUFACTURED FROM AUGUST 29, 2011, THROUGH FEBRUARY 19, 2012. THE VEHICLES HAVE A LOOSE CONNECTION IN THE JOINT BETWEEN THE STEERING PITMAN ARM AND THE STEERING DRAG LINK. THE JOINT MAY SEPARATE OVER TIME RESULTING IN LOSS OF STEERING CONTROL.
Hazard: A LOSS OF STEERING CONTROL COULD RESULT IN A CRASH, INCREASING THE RISK OF INJURY.
Remedy: NABI WILL INSPECT AND REPAIR VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING MARCH 2012. OWNERS MAY CONTACT NABI AT 1-256-831-4296.
Additional Info: NABI'S RECALL CAMPAIGN NUMBER IS 20121. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=12V118000
   
2011-08-30 (Published by NHTSA on 2011-08-30)
Recall Summary: NORTH AMERICAN BUS INDUSTRIES (NABI) IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 416 TRANSIT BUSES MANUFACTURED FROM SEPTEMBER 1, 2010, THROUGH FEBRUARY 28, 2011, EQUIPPED WITH A CUMMINS ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
Hazard: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.
Remedy: NABI IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR NABI AT 1-256-831-4296.
Additional Info: CUMMINS RECALL CAMPAIGN NUMBER IS C1154.NABI'S RECALL CAMPAIGN NUMBER IS 20111.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=11V444000
   
2010-01-14 (Published by NHTSA on 2010-01-14)
Recall Summary: NORTH AMERICAN BUS INDUSTRIES, INC. (NABI) IS RECALLING CERTAIN MODEL YEAR 2009 416 STANDARD MODEL FLOOR CITY TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 30, 2008, AND DECEMBER 18, 2009. THE MOUNTING PLATE THAT HOLDS THE STEERING GEAR ASSEMBLY MAY NOT HAVE BEEN SUFFICIENTLY WELDED.
Hazard: AN INSUFFICIENT WELD COULD LEAD TO A SEPARATION OR PARTIAL SEPARATION OF THE PLATE AND CAUSE THE DRIVER TO LOOSE PROPER STEERING CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.
Remedy: NABI WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 26, 2010. OWNERS MAY CONTACT NABI CUSTOMER SERVICE AT 1-256-831-4296 EXT. 1308.
Additional Info: NABI'S CAMPAIGN NUMBER IS 20101.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=10V011000
   
2009-12-29 (Published by NHTSA on 2009-12-29)
Recall Summary: NORTH AMERICAN BUS INDUSTRIES, INC. (NABI) IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN JANUARY 1, 2002, AND SEPTEMBER 15, 2009, AND EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
Hazard: THE CORROSION COULD CAUSE AN ELECTRICAL SHORT THAT COULD RESULT IN A FIRE.
Remedy: NABI WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JANUARY 2010. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR NABI AT 1-256-831-4296.
Additional Info: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=09V495000
   
2009-10-15 (Published by NHTSA on 2009-10-15)
Recall Summary: NABI IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2009 416 MODEL STANDARD FLOOR CITY TRANSIT BUSES MANUFACTURED FROM JANUARY 2001 THROUGH OCTOBER 5, 2009, EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS. THE LIFTS ARE EQUIPPED WITH A LOGIC BOARD ASSEMBLY FOR THE WHEELCHAIR LIFT CONTROL BOX, P/NOS. 373-0226 AND 373-0265. THE OUTBOARD RAMP BARRIER COULD FOLD IN TOWARD A LIFT PASSENGER POSSIBLY PINCHING THE PASSENGER'S FEET.
Hazard: THE LIFT PASSENGER COULD BE SERIOUSLY INJURED.
Remedy: NABI WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY LIFT-U FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 23, 2009. OWNERS MAY CONTACT LIFT-U AT 1-209-838-2400 OR NABI CUSTOMER SERVICE AT 1-888-424-5844 OR 1-256-831-4296 EXT. 1307.
Additional Info: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=09V404000
   
2007-04-20 (Published by NHTSA on 2007-04-20)
Recall Summary: ON CERTAIN TRANSIT BUSES EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS, IT IS POSSIBLE FOR A PERSON TO WEDGE THEIR FEET UNDER THE SOLID BAR BARRIER LINKAGE.
Hazard: WHILE SITTING IN A WHEEL CHAIR, A PERSON WITH NO SHOES WHO DOES NOT HAVE CONTROL OF THEIR FEET COULD TWIST THEIR FEET AND GET THEM FORCED UNDER THE LINKAGE WHICH COULD RESULT IN AN INJURY.
Remedy: LIFT-U IS CONDUCTING THIS RECALL (PLEASE SEE 06E-093). OWNERS WILL RECEIVE A FREE REPAIR KIT ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2007. OWNERS MAY CONTACT LIFT-U AT 209-838-2400 OR NABI AT 256-831-4296.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=07V172000
   
Advertisement

Advertisement

Additional Nabi Models

Recalls have also been issued under these model names:

Latest Safety Recalls

Select image for details, including additional styles.

 

Advertisement

Comments

Do you have comments or questions about this recall? Share them here.

Note: The recalling companies may not be monitoring these comments; they should be directed toward the public. Community Guidelines apply.

comments powered by Disqus
Back to Top



Sources may include: National Highway Traffic Safety Administration (NHTSA) and companies involved with this or a related recall.