feedback
facebook page
Follow Me on Pinterest
twitter page
google plus page
rss feed

Recalled Product

List of recalls for New Flyer D30lf

Search Recalls or Browse by Category
Consumer Products (?)
Food & Health (?)
Vehicles (?)

New Flyer D30lf Recalls

There have been 0 recalls on D30lf vehicles in recent years. The latest was issued on 2007-02-27 due to a problem with the exterior lighting. Approximately 1707 vehicles were involved. Since 1994, D30lf's have experienced approximately 11 recall(s) due to hazards with various components, including the diesel, equipment adaptive, fan, turbo-charger and tie rod assembly. See a list of recalls for your model year below.

IMPORTANT NOTE: Also check the list of Additional New Flyer Models to the right. At times, the manufacturer or the NHTSA may use slightly different model names, or group models together by series.

Recalled New Flyer D30lf vehicles

Do you work for New Flyer? Contact us to learn how you can control data, information and ads shown on this page.

Detailed Recall Information for New Flyer D30lf

Show Recalls for Model Year:
All
1994
1995
1996
1997
1998
1999
2000
2001
2002
2003
2004
2005
2006
2007-02-27 (Published by NHTSA on 2007-02-27)
Recall Summary: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.
Hazard: THE STANDARD REQUIRES THAT THE DECELERATION LAMP IS A SOLID LIGHT RATHER THAN A FLASHING LIGHT.
Remedy: DEALERS WILL REWIRE THE ELECTRICAL SYSTEM TO REMOVE THE FLASHING FUNCTION OR INSTALL A NEW PROGRAMMABLE LOGIC CONTROLLER (PLC) WHICH WILL MAKE THE LAMPS BURN STEADY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.
Additional Info: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION1S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=07V068000
   
2006-06-14 (Published by NHTSA on 2006-06-14)
Recall Summary: ON CERTAIN TRANSIT BUSES BUILT WITH CUMMINS ISL AND ISC DIESEL ENGINES EQUIPPED WITH THE CM850 FUEL SYSTEM, THE ENGINE HIGH PRESSURE FUEL LINES, FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL, ARE PRONE TO FAILURE.
Hazard: FAILURE OF THE LINE INTRODUCES HIGH PRESSURE FUEL SPRAY INTO THE ENGINE COMPARTMENT WHICH CAN IGNITE WHEN IT COMES IN CONTACT WITH A HOT SURFACE.
Remedy: CUMMINS WILL INSTALL A FUEL LINE BRACKET TO REDUCE FUEL LINE STRESS. A NEW FUEL LINE WILL BE INSTALLED WHEN ADDING THE BRACKET. CUSTOMERS MAY CONTACT CUMMINS AT 1-800-DIESELS OR NEW FLYER AT 204-934-4876.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=06V212000
   
2006-02-09 (Published by NHTSA on 2006-02-09)
Recall Summary: ON CERTAIN TRANSIT BUSES, THE SPOT WELDS WHICH HOLD THE WHEELCHAIR RAMP HINGE ASSEMBLY TOGETHER CAN FAIL ALLOWING THE RAMP TO SEPARATE, WHEN DEPLOYED UNDER LOAD, FROM THE BUS FRAME.
Hazard: SEPARATION OF THE RAMP FROM THE VEHICLE COULD RESULT IN INJURY TO PASSENGERS ON THE RAMP.
Remedy: DEALERS WILL ADD NEW HARDWARE TO THE HINGES WHICH WILL MAKE THE SPOT-WELDING REDUNDANT. THE RECALL BEGAN ON FEBRUARY 15, 2006. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=06V034000
   
2005-08-29 (Published by NHTSA on 2005-08-29)
Recall Summary: ON CERTAIN TRANSIT BUSES, HYDRAULIC FLUID CAN LEAK AT THE FLANGE FITTING DUE TO IMPROPER INSTALLATION PROCEDURES. INCORRECT INSTALLATION PROCEDURES MAY CAUSE DAMAGE TO THE O-RING OF THE FLANGE ASSEMBLY, COMPROMISING THE SEALING CAPABILITY OF THE O-RING.
Hazard: LEAKS CAUSED DUE TO DAMAGED O-RINGS COULD CAUSE HYDRAULIC FLUID TO BE SPRAYED ONTO HOT SURFACES AND IGNITE.
Remedy: NEW FLYER WILL CONTACT CUSTOMERS WITH PARTS AND INSTRUCTIONS ON HOW TO COMPLETE THIS RECALL. THE RECALL BEGAN ON AUGUST 30, 2005. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=05V370000
   
2005-07-14 (Published by NHTSA on 2005-07-14)
Recall Summary: ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE.
Hazard: THIS CAN RESULT IN A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSPECT AND REPLACE THE TURBOCHARGER TO PREVENT THE POSSIBILITY OF AN ENGINE COMPARTMENT FIRE. DETROIT DIESEL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR NEW FLYER AT 1-204-982-8400.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=05V320000
   
2005-03-29 (Published by NHTSA on 2005-03-29)
Recall Summary: ON CERTAIN TRANSIT BUSES EQUIPPED WITH MERITOR FRONT AXLE ASSEMBLIES, A WELD IS MISSING ON THE RADIUS ROD ATTACHMENT BRACKETAND THE BRACKET MAY FATIGUE AND FAIL WHILE IN USE.
Hazard: BRACKET FAILURE COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 6, 2005. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=05V116000
   
2002-05-21 (Published by NHTSA on 2002-05-21)
Recall Summary: ON CERTAIN BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Hazard: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Remedy: WILLIAMS CONTROLS IS HANDLING THE REPLACEMENT OF THIS PEDAL. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WILLIAMS CONTROL AT 1-503-684-8600 OR NEW FLYER AT 204-982-8181.
Additional Info: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=02V004008
   
2002-02-27 (Published by NHTSA on 2002-02-27)
Recall Summary: ON CERTAIN LOW FLOOR TRANSIT BUSES EQUIPPED WITH ADHESIVELY BONDED ALUMINUM BUS DOOR PANELS, DUE TO AN IMPERFECT BONDING OF THE DOOR PANEL SKIN TO THE PANEL FRAME, ENVIRONMENTAL MOISTURE MAY INFILTRATE REGIONS OF IMPERFECT BONDING AND CAUSE SEPARATION OF THE FRAME AND DOOR PANEL.
Hazard: UNDER THESE CONDITIONS, IF THE PANEL IS SEPARATING OR HAS SEPARATED, A PASSENGER COULD FALL FROM THE BUS ONTO THE ROADWAY, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Remedy: VAPOR WILL NOTIFY CUSTOMERS TO HAVE THEIR BUSES INSPECTED AND WILL INSTALL MECHANICAL FASTENERS TO ATTACH THE SKINS TO THE FRAME ELEMENTS FREE OF CHARGE. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VAPOR CORPORATION AT 847-967-8300 OR NEW FLYER AT 1-204-224-1251.
Additional Info: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=02V059001
   
2001-05-22 (Published by NHTSA on 2001-05-22)
Recall Summary: VEHICLE DESCRIPTION: TRANSIT BUSES. THERE COULD BE A CASTING DEFECT IN THE LEFT SIDE SPRING TOWER. THE SPRING TOWERS SUPPORT THE VEHICLE STRUCTURE, AND FAILURE OF A TOWER COULD CAUSE A SUDDEN SHIFT IN THE FRONT AXLE.
Hazard: THIS CONDITION COULD LEAD TO LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE SPRING TOWER. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEW FLYER AT 1-204-982-8181.
Additional Info: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=01V160000
   
2001-05-15 (Published by NHTSA on 2001-05-15)
Recall Summary: VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.
Hazard: WITHOUT FUSING, THE EQUALIZER MAY MELT, BURN, OR SMOKE, POSSIBLY RESULTING IN A FIRE OR A SMOKE FILLED BUS, THUS NECESSITATING A PASSENGER EVACUATION OF THE BUS. THE FAILURE MODE CAN CAUSE OPERATOR DISTRACTION, AND/OR POSSIBLE PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE BUSES FOR CERTAIN EQUALIZERS BY THE DATE CODE. THE AFFECTED EQUALIZERS WILL BE REPLACED BY VANNER. NEW FLYER IS CONDUCTING THE OWNER NOTIFICATION FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VANNER AT 1-800-227-6937 OR NEW FLYER AT 1-204-982-8413.
Additional Info: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=01V033006
   
2000-09-22 (Published by NHTSA on 2000-09-22)
Recall Summary: VEHICLE DESCRIPTION: TRANSIT BUSES. THE FRONT AXLE'S SPRING TOWER BOLTS MAY NOT HAVE BEEN ADEQUATELY TIGHTENED.
Hazard: INCORRECT BOLT TORQUE COULD LEAD TO A SHORTER BOLT FATIGUE LIFE AND EVENTUAL BOLT FAILURE.
Remedy: DEALERS WILL REINSTALL THE BOLTS TO THE CORRECT TORQUE.
Additional Info: OWNER NOTIFICATION BEGAN MARCH 16, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEW FLYER AT 1-204-982-8181. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=00V276000
   
Advertisement

Advertisement

Additional New Flyer Models

Recalls have also been issued under these model names:

Latest Safety Recalls

Select image for details, including additional styles.

 

Advertisement

Comments

Do you have comments or questions about this recall? Share them here.

Note: The recalling companies may not be monitoring these comments; they should be directed toward the public. Community Guidelines apply.

comments powered by Disqus
Back to Top



Sources may include: National Highway Traffic Safety Administration (NHTSA) and companies involved with this or a related recall.