feedback
facebook page
Follow Me on Pinterest
twitter page
google plus page
rss feed

Recalled Product

List of recalls for Pierce Arrow Xt

Search Recalls or Browse by Category
Consumer Products (?)
Food & Health (?)
Vehicles (?)
Home > Recalled Products > Vehicle Recalls > Pierce > Arrow Xt Recalls

Pierce Arrow Xt Recalls

There have been 24 recalls on Arrow Xt vehicles in recent years. The latest, dated 2016-08-05 and published by the NHTSA on 2016-09-01, was due to a problem with the manual transmission. Approximately 470 vehicles were involved. Since 1995, Arrow Xt's have experienced approximately 34 recall(s) due to hazards with various components, including the equipment, driveshaft, axle assembly, upper ball joint and lower arm. See a list of recalls for your model year below.

IMPORTANT NOTE: Also check the list of Additional Pierce Models to the right. At times, the manufacturer or the NHTSA may use slightly different model names, or group models together by series.

Recalled Pierce Arrow Xt vehicles

Do you work for Pierce? Contact us to learn how you can control data, information and ads shown on this page.

Detailed Recall Information for Pierce Arrow Xt

Show Recalls for Model Year:
All
1995
1996
1997
1998
1999
2000
2001
2002
2003
2004
2005
2006
2007
2008
2009
2010
2011
2012
2013
2014
2015
2016
2016-08-05 (Published by NHTSA on 2016-09-01)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow, Dash, Enforcer, Impel, Quantum, Saber, and Velocity fire trucks manufactured June 29, 2015, to June 30, 2016. The affected vehicles may be equipped with certain C20 and C21 split-shaft transmissions from Waterous. This transmission sends power to the wheels of an emergency response vehicle or power to an add-on unit such as a water pump used for fighting fires. A component within the shift unit may be damaged and as a result, the operator may not be able to switch the power output.
Hazard: If the power output cannot be changed, once the fire truck arrives at the scene, it may not be able to pump water to aid in extinguishing the fire, increasing the risk of injury.
Remedy: Piece will notify owners, and dealers will remove the shift unit assembly and replace the clevis pin and retaining rings, free of charge. The recall is expected to begin in September 2016. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B277.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V585000
   
2016-06-01 (Published by NHTSA on 2016-06-11)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow XT, Enforcer, Impel, Quantum, Saber, and Velocity emergency vehicles manufactured August 4, 2015, to August 24, 2016, equipped with pumps to provide pressurized water to aid in fighting fires. These pumps have 6" intake strainers that may have been improperly soldered during production and, as a result, the strainers may come apart during use, allowing parts of the strainer and debris to enter the pump, possibly damaging the pump.
Hazard: If the strainer and/or debris enters the pump, and the operator is forced to shut down the pump, reducing firefighting effectiveness, there could be an increased risk of injury.
Remedy: Pierce will notify owners to check the strainer for missing solder at the joints. Any strainers missing solder will be replaced, free of charge. The recall is expected to begin in June 2016. Owners may contact Pierce customer service at 1-888-974-3723 or Hale Products Customer Service Center at 1-800-533-3569. Pierce's number for this recall is 74B272.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V390000
   
2016-04-01 (Published by NHTSA on 2016-04-16)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2010-2016 Arrow-XT, Quantum, and Velocity vehicles manufactured from October 30, 2010, through January 24, 2016. The affected vehicles are equipped with Pelican 9410L flashlights, part number 9410-021-245 or 9410-021-110, with lithium ion battery packs which may overheat.
Hazard: If the flashlight battery pack overheats, it can increase the risk of a fire.
Remedy: Pierce will notify owners and instruct them to inspect the flashlight and battery pack, and if necessary, to request a replacement battery pack from Pelican Products, free of charge. The recall is expected to begin on, or about, April 15, 2016. Owners may contact Pierce customer service at 1-414-832-3000. Pierce's recall number for this campaign is 74B271.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V186000
   
2016-03-02 (Published by NHTSA on 2016-03-19)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2016 Arrow-XT, Dash, Enforcer, Impel, Quantum, Saber, and Velocity fire and emergency vehicles manufactured October 13, 2015, to February 9, 2016. The fastener cap over the bearing on the universal joint of the drive shaft may have been improperly tightened.
Hazard: If the cap was not properly tightened, the cap may detach from the vehicle and become a road hazard. Additionally, the universal joint may separate and the vehicle may not be able to be driven, increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will check and correct the tightness of all bolts for the universal joint caps, as needed, free of charge. The recall is expected to begin in March 2016. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B270.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V123000
   
2015-11-16 (Published by NHTSA on 2015-12-11)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2013-2015 Arrow XT, Quantum, Velocity, Impel, and Saber fire-fighting vehicles manufactured June 19, 2013, to July 31, 2014. The affected vehicles have fire hose water pressure regulators that may not respond consistently to operator input and, as a result, there may be an unexpected water pressure surge to the fire hose.
Hazard: An unexpected surge in water pressure to the fire hose can increase the risk of injury to the hose operator or those nearby.
Remedy: Pierce will notify owners, and dealers will update the water pressure governor firmware, free of charge. The recall is expected to begin in December 2015. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B252.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V760000
   
2015-10-26 (Published by NHTSA on 2015-11-07)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow XT, Velocity, Enforcer, and Saber vehicles manufactured November 20, 2014, to September 29, 2015. The affected vehicles are equipped with front drive axles whose hex nuts on the flange yoke may not have been properly tightened.
Hazard: If the hex nuts are not tightened to specification, the driveshaft may disconnect from the drive axle, resulting in a loss of propulsion and increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will inspect the hex nuts, tightening them as necessary, free of charge. The recall is expected to begin November 9, 2015. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B266.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V706000
   
2015-10-01 (Published by NHTSA on 2015-11-18)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2006-2007 Arrow XT, Dash, Enforcer, Lance, and Quantum vehicles manufactured January 1, 2006, to March 31, 2007. In the affected vehicles, tears in the ball joint protective boots may result in contamination of the ball joints.
Hazard: The contamination may cause premature ball joint failure and the wheel to disengage from the control arm, increasing the risk of a vehicle crash.
Remedy: Pierce will notify owners, and dealers will inspect the affected vehicles for torn ball joint boots. Pierce will also evaluate the ball joint wear. Ball joints with an unexpected level of wear will be replaced. These repairs will be performed free of charge. The recall is expected to begin November 30, 2015. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B267.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V615000
   
2015-08-13 (Published by NHTSA on 2015-09-09)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2014-2015 Pierce Arrow XT, Dash CF, Enforcer, Quantum, and Velocity emergency vehicles manufactured from November 3, 2014, through July 31, 2015. The affected vehicles have a driveshaft that may bend or twist possibly causing it disconnect.
Hazard: If the driveshaft disconnects from the vehicle, the vehicle would have a loss of drive, disabling it on the roadway and preventing the vehicle from responding to an emergency. Additionally, portions of the driveshaft could become a road hazard. These scenarios may increase the risk of a crash.
Remedy: Pierce has notified owners, and dealers will install a stronger driveshaft, free of charge. A second notice will be mailed to owners during September 2015 when parts are expected to be available. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B265.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V516000
   
2014-10-21 (Published by NHTSA on 2014-11-05)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2009-2013 Pierce Enforcer, Impel, Quantum, Velocity, and Arrow XT emergency vehicles manufactured November 11, 2009, to April 23, 2013, and equipped with TAK-4 front independent suspensions. The affected vehicles have front lower control arms that may crack and fracture.
Hazard: If one of the lower control arm fractures, the attached wheel may separate, increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will inspect and replace the lower control arms, as necessary, free of charge. The recall is expected to begin in November 2014. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B257.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V660000
   
2014-05-13 (Published by NHTSA on 2014-05-13)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2013 Arrow XT, Dash CF, Impel, and Velocity vehicles manufactured October 2013 through January 2014, and equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."
Hazard: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.
Remedy: Pierce will notify owners, and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall began on June 26, 2014. Owners may contact Pierce at 1-888-974-3723. Pierce's number for this campaign is 74B246.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=14V243000
   
2013-11-07 (Published by NHTSA on 2013-11-30)
Recall Summary: Pierce Manufacturing Inc. (Pierce) is recalling certain model year 2000-2009 Enforcer and 2000-2010 Dash, Lance, and Arrow XT vehicles manufactured October 1, 2000, through May 31, 2010. The trunnion ears on which the cab tilt cylinders pivot may fatigue and fail.
Hazard: If in the path of the moving cab when the a trunnion fails, a person may suffer personal injury.
Remedy: Pierce will notify owners, and dealers will affix new safety signs, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Pierce at 1-920-832-3000. Pierce's recall number is 74B240.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V525000
   
2013-11-06 (Published by NHTSA on 2013-12-03)
Recall Summary: Pierce Manufacturing Inc. (Pierce) is recalling one model year 2009 Enforcer emergency vehicle and certain model year 2009-2013 Arrow XT, Saber, Velocity, Impel, Quantum, and Commercial vehicles. The trailer connector circuit was wired such that the stop signal overrides the turn signal and the trailer lights do not indicate a turn when brakes are applied.
Hazard: The absence of trailer turn signals may confuse other drivers, increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will install a new electrical harness, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Pierce at 1-920-832-3000. Pierce's recall number is 74B244.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V518000
   
2013-09-30 (Published by NHTSA on 2013-10-22)
Recall Summary: Pierce Manufacturing Inc. is recalling certain model year 2012-2013 Arrow XT and Velocity emergency vehicles, manufactured January 1, 2012, through June 14, 2013 and equipped with quarter-turn ball valves installed between the glad hands connectors and the parking brake system. If the ball valves are left in the closed position, air pressure can build up on the parking brake circuit side and prevent the application of the spring park brakes when the parking brake valve is activated in the cab.
Hazard: This may allow the vehicle to unexpectedly roll, increasing the risk of personal injury or a vehicle crash.
Remedy: Pierce will notify owners, and dealers will remove the quarter turn ball valves and connect the glad hand signal hose into the primary air tank, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Pierce at 1-920-832-3000. Pierce's recall number is 74B243.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=13V435000
   
2012-07-02 (Published by NHTSA on 2012-07-02)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2010-2012 VEHICLES MANUFACTURED FROM AUGUST 28, 2010, THROUGH MARCH 27, 2012, EQUIPPED WITH DETROIT DIESEL DD13 EPA 2007 AND EPA 2010 DIESEL ENGINES. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.
Hazard: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: PIERCE WILL NOTIFY OWNERS, AND THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DAIMLER TRUCK NORTH AMERICA (DTNA) AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 18, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712 OR PIERCE MANUFACTURING, INC. AT 1-920-832-3000.
Additional Info: THIS IS PIERCE'S RECALL NUMBER 74B233.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=12V311000
   
2012-02-29 (Published by NHTSA on 2012-02-29)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2010-2012 ARROW XT, DASH CF, QUANTUM AND VELOCITY EMERCENCY VEHICLES MANUFACTURED FROM OCTOBER 13, 2010, THROUGH FEBRUARY 8, 2012, AND EQUIPPED WITH DETROIT DIESEL DD13 EPA 2010 ENGINES. THE ENGINE SHUTDOWN SOFTWARE NORMALLY PROVIDED TO PROTECT THE ENGINE AND VEHICLE MAY NOT HAVE BEEN DISABLED ON ENGINES INTENDED FOR EMERGENCY VEHICLE APPLICATIONS.
Hazard: IF THE VEHICLE OPERATOR RECEIVES AND IGNORES MULTIPLE WARNINGS INDICATING THE NEED FOR OPERATOR INTERVENTION, THE ENGINE MAY SHUT DOWN UNEXPECTEDLY. UNEXPECTED EMERGENCY VEHICLE ENGINE SHUTDOWN UNDER CERTAIN CONDITIONS COULD HAMPER RESCUE OPERATIONS AND PLACE THE PUBLIC AT RISK.
Remedy: PIERCE WILL NOTIFY OWNERS, AND DETROIT DIESEL DEALERS WILL DISABLE THE ENGINE SHUTDOWN SOFTWARE, FREE OF CHARGE. PIERCE HAS NOT PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT PIERCE AT 888-974-3723.
Additional Info: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATIONÂżS VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=12V080000
   
2011-11-18 (Published by NHTSA on 2011-11-18)
Recall Summary: PIERCE MANUFACTURING (PIERCE) IS RECALLING CERTAIN MODEL YEAR 2005, 2008-2011 ARROW XT, CUSTOM CONTENDER, DASH, ENFORCER, IMPEL, QUANTUM, SABER, AND VELOCITY 75 FOOT HAL (HEAVY ALUMINUM LADDER) FIRE APPARATUS BODIES VEHICLES MANUFACTURED FROM MAY 17,2005, THROUGH OCTOBER 13, 2011, THAT MAY BE EQUIPPED WITH DUAL SCBA CYLINDER STORAGE COMPARTMENTS. THESE COMPARTMENTS EXTEND INBOARD HORIZONTALLY FROM THE SIDE OF THE REAR BODY. THE SCBA COMPARTMENT DOOR LATCH ORIENTATION MAY HAVE BEEN MANUFACTURED INCORRECTLY, ALLOWING THE DOOR TO ACCIDENTALLY OPEN WHILE THE VEHICLE IS IN MOTION. THE DOOR MAY OPEN WITHOUT WARNING AND WITHOUT KNOWLEDGE TO THE DRIVER.
Hazard: IF THE DOOR OPENS, THE SCBA CYLINDERS MAY FALL OUT OF THE COMPARTMENT AND ONTO THE ROADWAY, INCREASING THE RISK OF A CRASH OR INJURY TO PEDESTRIANS.
Remedy: PIERCE DEALERS WILL NOTIFY OWNERS, AND WILL INSTALL A FLAT REINFORCEMENT PLATE THAT SPANS THE LENGTH OF THE SCBA DOOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 5, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
Additional Info: PIERCE SAFETY RECALL NUMBER IS 74B186.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=11V551000
   
2011-11-02 (Published by NHTSA on 2011-11-02)
Recall Summary: PIERCE MANUFACTURING (PIERCE) IS RECALLING CERTAIN MODEL YEAR 2007-2011 ARROW XTAND VELOCITY, MODEL YEAR 2008-2011 CUSTOM CONTENDER, IMPEL, QUANTUM AND MODEL YEAR 2009-2011 SABER EMERGENCY TRUCKS, EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES, MANUFACTURED FROM DECEMBER 19, 2007, THROUGH OCTOBER 7, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
Hazard: IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.
Remedy: PIERCE IS WORKING WITH MERITOR WABCO AND WILL REPLACE THE CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2011. OWNERS MAY CONTACT MERITOR WABCO AT 1-248-435-8001 OR PIERCE AT 1-920-832-3000.
Additional Info: THE NHTSA NUMBER ASSIGNED TO THE MERITOR WABCO'S RECALL IS 11E-039.PIERCE'S SAFETY RECALL NUMBER IS 74B226.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=11V527000
   
2011-08-18 (Published by NHTSA on 2011-08-18)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2011 ARROW XT, CUSTOM CONTENDER, DASH CF, IMPEL, SABER, AND VELOCITY EMERGENCY VEHICLES MANUFACTURED FROM JANUARY 24, 2011, THROUGH APRIL 19, 2011, EQUIPPED WITH A CUMMINS ISB, ISX, ISC, OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
Hazard: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.
Remedy: PIERCE IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR PIERCE AT 1-920-832-3000.
Additional Info: CUMMINS RECALL CAMPAIGN NUMBER IS C1154.PIERCE'S RECALL CAMPAIGN NUMBER IS 74B221.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=11V422000
   
2011-07-28 (Published by NHTSA on 2011-07-28)
Recall Summary: PIERCE HAS DECIDED THAT CERTAIN MODEL YEAR 1995-2008 ARROW XT, DASH, CUSTOM CONTENDER, LANCE, ENFORCER, PIERCE ARROW, QUANTUM, SABER AND COMMERCIAL FIRE TRUCKS MANUFACTURED FROM JANUARY 2, 1995, THROUGH JANUARY 21, 2008, CONTAIN A SAFETY DEFECT. THESE VEHICLES ARE EQUIPPED WITH FUEL TANK STRAPS THAT MAY CORRODE DUE TO WINTER ROAD SALT OR LIQUID DE-ICING CHEMICALS. IF THE FUEL TANK STRAPS CORRODE SUFFICIENTLY, THE FUEL TANK SUPPORTING STRAPS MAY FRACTURE AND THE FUEL TANK MAY FALL FROM THE VEHICLE.
Hazard: THE VEHICLES MAY LOSE POWER AND STALL. IN ADDITION, THE FUEL TANK MAY RUPTURE AND SPILL DIESEL FUEL ON THE ROADWAY. EITHER OF THESE OUTCOMES MAY CAUSE A FIRE TRUCK OR SURROUNDING VEHICLES TO SLIP OR SLIDE ON THE ROADWAY SURFACE, INCREASING THE RISK OF A CRASH.
Remedy: FOR FIRE TRUCKS THAT ARE LESS THAN 10 YEARS OLD, DEALERS WILL INSPECT THE FUEL TANK STRAPS AND REPLACE THEM IF NECESSARY WITH STAINLESS STEEL STRAPS FREE OF CHARGE. FOR VEHICLES THAT ARE OLDER THAN 10 YEARS, PIERCE IS NOT OFFERING A FREE REMEDY, BUT WILL OFFER FOR PURCHASE REPLACEMENT FUEL TANKS STRAPS AND PROVIDE INSTRUCTIONS FOR INSTALLATION. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
Additional Info: PIERCE SAFETY RECALL NO. 74B218.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=11V384000
   
2011-04-28 (Published by NHTSA on 2011-04-28)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 1999-2008 ARROW XT, DASH, LANCE, AND ENFORCER FIRE APPARATUS MANUFACTURED FROM JUNE 22, 1999, THROUGH MAY 12, 2008, AND EQUIPPED WITH AN ELECTRONIC ACCELERATOR PEDAL. AFTER REPEATED USE WITH EXCESSIVE FORCE, THE ACCELERATOR PEDAL ARM MAY BEND AND CAUSE THE PEDAL TO MOVE CLOSER TO THE FLOOR. IF THE PEDAL ARM BENDS FAR ENOUGH, THE PEDAL MAY CONTACT THE CAB FLOOR WITHOUT WARNING AND STICK IN THE FULL THROTTLE POSITION.
Hazard: IF THE ACCELERATOR PEDAL BECOMES STUCK, THE OPERATOR MAY LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REMOVE THE EXISTING ACCELERATOR ARM AND INSTALL A REDESIGNED PEDAL ARM FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
Additional Info: PIERCE SAFETY RECALL NO. 74B215.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=11V255000
   
2011-04-12 (Published by NHTSA on 2011-04-12)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2009-2011 ARROW XT AND VELOCITY FIRE APPARATUS MANUFACTURED FROM JUNE 30, 2009, THROUGH MARCH 15, 2011. THE FRONT AXLE OF THESE VEHICLES WERE BUILT WITH MICHELIN 365/70R22.5 XZA TIRES INSTALLED ON 12.25 INCH WIDE WHEELS. THESE TIRES REQUIRE 10.5 INCH WIDE WHEELS. THEREFORE, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Hazard: THE WIDER 12.25 INCH WHEEL MAY CAUSE THE TIRE BEAD TO SEPARATE FROM THE RIM. THIS TIRE BEAD SEPARATION CAN CAUSE A TIRE FAILURE THAT MAY CAUSE THE VEHICLE TO CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL NEW 10.5 INCH WIDE WHEELS AND NEW MICHELIN 365/70R22.5 ZXA TIRES ON THE FRONT AXLE OF THE FIRE APPARATUS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 15, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
Additional Info: PIERCE'S RECALL CAMPAIGN NUMBER IS 74B213.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=11V230000
   
2011-02-16 (Published by NHTSA on 2011-02-16)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2008-2009 ARROW XT VEHICLES BUILT WITH CATERPILLAR C13 2007 ENGINES. THE THREE UPPER AIR CLEANER BRACKET FASTENERS MAY LOOSEN AND FALL OUT. IF THIS OCCURS THE AIR CLEANER AND BRACKET MAY FALL ONTO THE ENGINE AND START A FIRE.
Hazard: IF AN UNDER CAB FIRE OCCURS, THE ENGINE OPERATION COULD BE AFFECTED AND A CRASH MAY OCCUR.
Remedy: PIERCE WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2011. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.
Additional Info: PIERCE SAFETY RECALL NO. 74B211.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=11V097000
   
2010-09-22 (Published by NHTSA on 2010-09-22)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2008 ARROW XT, LANCE, VELOCITY, ENFORCER, IMPEL, AND DASH CUSTOM FIRE APPARATUS VEHICLES MANUFACTURED FROM MAY 30, 1998 THROUGH NOVEMBER 25, 2008. THE STEERING GEAR BRACKET MAY FRACTURE AND BREAK. IF THIS OCCURS THE STEERING GEAR MAY DETACH FROM THE VEHICLE.
Hazard: DETACHMENT OF THE STEERING GEAR WILL RESULT IN A LOSS OF STEERING CONTROL THAT COULD CAUSE A CRASH.
Remedy: PIERCE WILL NOTIFY OWNERS AND DEALERS WILL INSTALL A NEW STEERING GEAR MOUNTING BRACKET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 12, 2010. OWNERS ARE BEING INSTRUCTED TO INSPECT THE STEERING GEAR BRACKET PRIOR TO EACH TRIP. THE REMEDY TO REPAIR THIS DEFECT IS EXPECTED TO BEGIN NO EARLIER THE JANUARY 31, 2011. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.
Additional Info: PIERCE SAFETY RECALL NO. 74B207.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=10V423000
   
2010-07-08 (Published by NHTSA on 2010-07-08)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ARROW XT, DASH, ENFORCER, IMPEL, QUANTUM, AND VELOCITY FIRE TRUCKS MANUFACTURED FROM OCTOBER 11, 2006 THROUGH JUNE 16, 2010 AND EQUIPPED WITH MERITOR WABCO EX225 REAR DISC BRAKES AND ONSPOT AUTOMATIC TIRE CHAINS. THE MERITOR WABCO EX225 REAR DISC BRAKE CALIPER MAY INTERFERE WITH THE ONSPOT AUTOMATIC TIRE CHAIN BRACKETS. THIS INTERFERENCE MAY RESTRICT THE CALIPER FROM FULL MOVEMENT.
Hazard: IF THIS INTERFERENCE OCCURS, BRAKING PERFORMANCE MAY BE REDUCED WITHOUT WARNING AND A CRASH MAY OCCUR.
Remedy: DEALERS WILL INSTALL NEW AUTOMATIC TIRE CHAIN BRACKETS. THE NEW BRACKETS PROVIDE ADDITIONAL CLEARANCE FOR THE FULL ACTUATION OF THE DISC BRAKE CALIPERS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN IN JULY 2010. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
Additional Info: PIERCE SAFETY RECALL NO. 39-0139830. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=10V317000
   
2010-06-16 (Published by NHTSA on 2010-06-16)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2010 ARROW XT, QUANTUM, AND VELOCITY EMERGENCY VEHICLES MANUFACTURED FROM AUGUST 11, 2009, THROUGH MAY 20, 2010. THE REAR BRAKE SLACK ADJUSTERS MAY INTERFERE WITH THE AUTOMATIC TIRE CHAIN BRACKETS. THE INTERFERENCE OCCURS AT NEAR FULL STROKE OF THE SLACK ADJUSTERS. DUE TO THE VARYING AUTOMATIC SLACK ADJUSTER MOVEMENT, THE SLACK ADJUSTER MAY CONTACT THE TIRE CHAIN BRACKET.
Hazard: IF THIS INTERFERENCE OCCURS, THE BRAKE CAPABILITY MAY BE COMPROMISED AND A CRASH MAY OCCUR WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW AUTOMATIC TIRE CHAIN BRACKET FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2010. OWNER MAY CONTACT PIERCE AT 1-920-832-3000.
Additional Info: PIERCE'S SAFETY RECALL NO. 39-0139830.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=10V269000
   
2010-05-10 (Published by NHTSA on 2010-05-10)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ARROW XT, DASH, LANCE, QUANTUM, AND VELOCITY EMERGENCY VEHICLES MANUFACTURED FROM DECEMBER 20, 2006, THROUGH FEBRUARY 1, 2010, EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES. THE ENGINE MAY SHUT DOWN UNEXPECTEDLY WHEN A DIESEL PARTICULATE FILTER OVER TEMPERATURE CONDITION IS DETECTED.
Hazard: UNEXPECTED EMERGENCY VEHICLE ENGINE SHUTDOWN UNDER CERTAIN CONDITIONS COULD HAMPER RESCUE OPERATIONS AND PLACE THE PUBLIC AT RISK.
Remedy: OWNERS WILL BE NOTIFIED BY DETROIT DIESEL AND DETROIT DIESEL WILL REPAIR THE VEHICLES FREE OF CHARGE BY REPROGRAMMING THE ENGINE CONTROL LOGIC TO ILLUMINATE A MALFUNCTION INDICATOR LIGHT WITHOUT REQUESTING ENGINE SHUTDOWN. PLEASE SEE DAIMLER TRUCKS' DEFECT REPORT 10E-005. THE SAFETY RECALL BEGAN ON MAY 28, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR PIERCE AT 1-920-832-3000.
Additional Info: PIERCE'S RECALL CAMPAIGN NUMBER IS 39-0139830.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=10V195000
   
2009-10-06 (Published by NHTSA on 2009-10-06)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 FIRE TRUCKS MANUFACTURED BETWEEN APRIL 1, 2008 AND SEPTEMBER 30, 2009, EQUIPPED WITH CUMMINS ISB CM2150, ISC CM2150, ISL CM2150, ISM CM876, AND ISX CM871 MODEL DIESEL ENGINES. THE VEHICLES MAY BE DESIGNED WITH A HARD WIRED, DASH-MOUNTED SWITCH THAT ENABLES THE VEHICLE OPERATOR TO INHIBIT AFTERTREATMENT DIESEL PARTICULATE FILTER REGENERATION IN ENVIRONMENTS WHERE THE OPERATOR BELIEVES IT MAY BE UNSAFE FOR ELEVATED EXHAUST TEMPERATURES. DUE TO AN ISSUE WITH THE LOGIC IN THE ECM SOFTWARE IN THESE ENGINES, THE SWITCH MAY NOT FUNCTION CORRECTLY, LEADING THE OPERATOR TO BELIEVE THAT THE SWITCH IS IN "INHIBIT" MODE WHEN IT IS NOT.
Hazard: THIS CONDITION WILL PERMIT HOT EXHAUST GASES TO EXIT THE VEHICLE TAILPIPE, INCREASING THE RISK OF MELTING OR BURNING OF NEARBY SURFACES, OR A FIRE.
Remedy: PIERCE IS WORKING WITH CUMMINS TO REPAIR THE ENGINES. CUMMINS IS CONDUCTING THIS CAMPAIGN AND WILL PROVIDE THE REMEDY FREE OF CHARGE. PLEASE SEE CUMMINS RECALL CAMPAIGN 09E-046. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2009. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS (1-800-343-7357) OR PIERCE AT 1-920-832-3000.
Additional Info: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=09V389000
   
2009-08-31 (Published by NHTSA on 2009-08-31)
Recall Summary: PIERCE IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 FIRE TRUCKS EQUIPPED WITH SIDE-ROLL PROTECTION SYSTEMS. THE SENSOR DESIGNED TO DETECT VEHICLE ROLL CAN MALFUNCTION RESULTING IN AN INADVERTENT DEPLOYMENT OF THE PROTECTION SYSTEM.
Hazard: INADVERTENT DEPLOYMENT OF THE SIDE-ROLL PROTECTION SYSTEM COULD RESULT IN A VEHICLE CRASH OR INJURY TO AN OUT OF POSITION OCCUPANT.
Remedy: PIERCE WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 31, 2009. OWNERS MAY CONTACT PIERCE TOLL-FREE AT 1-888-974-3723.
Additional Info: PIERCE'S RECALL CAMPAIGN NUMBER 39-0139830.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=09V341000
   
2009-06-08 (Published by NHTSA on 2009-06-08)
Recall Summary: PIERCE IS RECALLING 185 MODEL YEAR 2008 AND 2009 CUSTOM FIRE TRUCKS MANUFACTURED BETWEEN JANUARY 1, 2008 AND MAY 31, 2009, EQUIPPED WITH MERITOR WABCO STEERING ANGLE SENSORS (SAS). INTERNAL FRICTION CAN DEVELOP BETWEEN THE SENSOR GEARS AND THE SENSOR HOUSING AS A RESULT OF EXTERNAL FORCES EXPERIENCED ON THE VEHICLE INCLUDING VIBRATION. IF DEVELOPED FRICTION IS GREAT ENOUGH, THE DRIVING TAB OF THE SAS CAN SHEAR AS THE DRIVER TURNS THE STEERING WHEEL.
Hazard: WITH A BROKEN SAS DRIVING TAB, THE ELECTRONIC STABILITY CONTROL (ESC) WILL NOT FUNCTION PROPERLY, WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: PIERCE WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 2, 2009. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
Additional Info: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=09V203000
   
2009-04-28 (Published by NHTSA on 2009-04-28)
Recall Summary: PIERCE MANUFACTURING IS RECALLING 257 MY 2008 EMERGENCY VEHICLES MANUFACTURED BETWEEN JUNE 1 AND OCTOBER 31, 2008, EQUIPPED WITH TRIMARK DOOR LATCHES. THESE LATCHES FAIL TO COMPLY WITH THE TRANSVERSE PULL STATIC LOAD REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." THE LATCHES MAY "POP" INTO THE SECONDARY LOCKING POSITION.
Hazard: IN THE EVENT OF A VEHICLE CRASH, THE DOOR WOULD NOT HAVE PRIMARY CLOSING SECURITY WHICH COULD POSSIBLY LEAD TO INJURY OF THE VEHICLE OCCUPANT.
Remedy: PIERCE WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT PIERCE CUSTOMER SERVICE TOLL-FREE AT 1-888-974-3723.
Additional Info: PIERCE'S RECALL NO. 39-0139830.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=09V137000
   
2008-10-31 (Published by NHTSA on 2008-10-31)
Recall Summary: PIERCE IS RECALLING 76 MY 2007-2008 ARROW XT AND VELOCITY FIRE TRUCKS EQUIPPED WITH CATERPILLAR C13 DIESEL ENGINES. THE EXTENSION PIPES ATTACHED TO THE AFTERTREATMENT REGENERATION DEVICE (ARD) MAY DEVELOP A HOLE, AND HEAT AND FLAME MAY ESCAPE DURING A REGENERATION OF THE DIESEL PARTICULATE FILTER.
Hazard: THIS MAY RESULT IN A FIRE HAZARD.
Remedy: PIERCE IS WORKING WITH CATERPILLAR TO REPAIR THESE VEHICLES (PLEASE SEE 08E054). OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986 OR PIERCE AT 1-920-832-3000.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=08V574000
   
2008-01-15 (Published by NHTSA on 2008-01-15)
Recall Summary: ON CERTAIN FIRE TRUCKS EQUIPPED WITH TRW STEERING GEARS, MODELS TAS85 AND RCS85, THESE STEERING GEARS CONTAIN POTENTIALLY DEFECTIVE SECTOR SHAFTS WITH AN INCORRECT GEAR TOOTH WHICH MAY INTERFERE WITH THE RACK-PISTON TEETH, RESULTING IN A STICK OR BIND CONDITION.
Hazard: THIS CONDITION HAS THE POTENTIAL TO CAUSE THE STEERING GEAR TO STALL AND RESTRICT THE STEERING TURNING ANGLE OF THE VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: PIERCE IS WORKING WITH TRW TO REPLACE THE DEFECTIVE STEERING GEAR (PLEASE SEE 07E101). THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS ONTACT TRW AT 765-429-1768 OR PIERCE AT 920-832-3249.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=08V020000
   
2005-08-09 (Published by NHTSA on 2005-08-09)
Recall Summary: ON CERTAIN FIRE TRUCKS, INTERFERENCE MAY OCCUR BETWEEN THE AERIAL FRONT AXLE INTERLOCK SENSOR BRACKET AND THE FRONT AIR BRAKE HOSE. THIS CONDITION OCCURS DURING FULL TURN STEERING AND FULL SUSPENSION JOUNCE COMPRESSION.
Hazard: THIS INTERFERENCE MAY CAUSE CHAFING LEADING TO A POTENTIAL FRONT AIR BRAKE HOSE FAILURE. IN THE EVENT OF A FRONT BRAKE HOSE FAILURE, LOSS OF FRONT BRAKING WILL OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REMOVE THE EXISTING FRONT AXLE INTERLOCK SENSOR BRACKET AND INSTALL A NEW BRACKET IN A NEW LOCATION AVOIDING THE FRONT AXLE BRAKE HOSE. THE RECALL BEGAN ON OCTOBER 13, 2005. OWNERS MAY CONTACT PIERCE AT 920-832-3249.
Additional Info: CUSTOMERS MAYALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=05V355000
   
2005-05-13 (Published by NHTSA on 2005-05-13)
Recall Summary: CERTAIN FIRE TRUCKS EQUIPPED WITH HOLLAND/NEWAY AIR SUSPENSION SYSTEMS, A TRANSVERSE BEAM CASTINGS MAY FRACTURE UNDER NORMAL LOADS. IF A CASTING BREAKS WHEN THE VEHICLE IS TRAVELING ON A ROADWAY THERE IS THE POTENTIAL FOR PIECES OF THE CASTING TO BECOME PROJECTILES AND THE SUSPENSION?S TRANSVERSE BEAM MAY DROP DOWN LOW ENOUGH TO CONTACT THE ROAD SURFACE.
Hazard: THIS WILL CAUSE SPARKS THAT COULD POTENTIALLY IGNITE AND CAUSE A FIRE.
Remedy: HOLLAND IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE DEFECTIVE TRANSVERSE BEAM ASSEMBLIES FREE OF CHARGE. OWNERS MAY CONTACT HOLLAND AT 616-396-6501 OR PIERCE AT 1-888-974-3723.
Additional Info: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=05V220000
   
Advertisement

Advertisement

Additional Pierce Models

Recalls have also been issued under these model names:

Latest Safety Recalls

Select image for details, including additional styles.

 

Advertisement

Comments

Do you have comments or questions about this recall? Share them here.

Note: The recalling companies may not be monitoring these comments; they should be directed toward the public. Community Guidelines apply.

comments powered by Disqus
Back to Top



Sources may include: National Highway Traffic Safety Administration (NHTSA) and companies involved with this or a related recall.