feedback
facebook page
Follow Me on Pinterest
twitter page
google plus page
rss feed

Recalled Product

List of recalls for Pierce Arrow Xt

Search Recalls or Browse by Category
Consumer Products (?)
Food & Health (?)
Vehicles (?)
Home > Recalled Products > Vehicle Recalls > Pierce > Arrow Xt Recalls

Pierce Arrow Xt Recalls

There have been 24 recalls on Arrow Xt vehicles in recent years. The latest, dated 2017-09-15 and published by the NHTSA on 2017-09-30, was due to a problem with the steering. Since 1995, Arrow Xt's have experienced approximately 38 recall(s) due to hazards with various components, including the equipment, axle shaft, suspension, manual transmission and driveshaft. See a list of recalls for your model year below.

IMPORTANT NOTE: Also check the list of Additional Pierce Models to the right. At times, the manufacturer or the NHTSA may use slightly different model names, or group models together by series.

Recalled Pierce Arrow Xt vehicles

Do you work for Pierce? Contact us to learn how you can control data, information and ads shown on this page.

Detailed Recall Information for Pierce Arrow Xt

Show Recalls for Model Year:
All
1995
1996
1997
1998
1999
2000
2001
2002
2003
2004
2005
2006
2007
2008
2009
2010
2011
2012
2013
2014
2015
2016
2017
2017-09-15 (Published by NHTSA on 2017-09-30)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain 2015-2016 Arrow XT, Enforcer, Impel, Quantum, Saber, and Velocity vehicles, equipped with certain Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Hazard: If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall is expected to begin in October 2017. Owners may contact Pierce customer service at 1-414-832-3000.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=17V570000
   
2017-07-21 (Published by NHTSA on 2017-08-04)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain 2016-2017 Arrow XT, Enforcer, Impel, Quantum, and Velocity fire trucks equipped with Hale Pump Interlock Module Kits. The Hale interlock pressure switch can fail after prolonged exposure to extreme cold temperatures, preventing the fire truck water pump from operating.
Hazard: If the fire truck cannot pump water during a fire emergency, there would be an increased risk of injury.
Remedy: Pierce will notify owners, and Hale Products dealers will replace the interlock modules, free of charge. The recall is expected to begin August 4, 2017. Owners may contact Hale customer service at 1-800-533-3569 or Pierce customer service at 1-414-832-3000. Pierce's number for this recall is 74B281.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=17V455000
   
2017-05-31 (Published by NHTSA on 2017-06-10)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain 2012-2017 Arrow XT, Dash, Enforcer, Quantum, and Velocity fire trucks equipped with the T3 rear steer option. The affected vehicles have a rear sway bar that may detach from the vehicle.
Hazard: If the sway bar detaches, the vehicle may sway more during steering maneuvers, increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will replace and properly torque the sway bar fasteners, free of charge. The recall is expected to begin on June 9, 2017. Owners may contact Pierce customer service at 1-888-974-3723.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=17V349000
   
2016-08-05 (Published by NHTSA on 2016-09-01)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow, Dash, Enforcer, Impel, Quantum, Saber, and Velocity fire trucks manufactured June 29, 2015, to June 30, 2016. The affected vehicles may be equipped with certain C20 and C21 split-shaft transmissions from Waterous. This transmission sends power to the wheels of an emergency response vehicle or power to an add-on unit such as a water pump used for fighting fires. A component within the shift unit may be damaged and as a result, the operator may not be able to switch the power output.
Hazard: If the power output cannot be changed, once the fire truck arrives at the scene, it may not be able to pump water to aid in extinguishing the fire, increasing the risk of injury.
Remedy: Piece will notify owners, and dealers will remove the shift unit assembly and replace the clevis pin and retaining rings, free of charge. The recall is expected to begin in September 2016. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B277.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V585000
   
2016-06-01 (Published by NHTSA on 2016-06-11)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow XT, Enforcer, Impel, Quantum, Saber, and Velocity emergency vehicles manufactured August 4, 2015, to August 24, 2016, equipped with pumps to provide pressurized water to aid in fighting fires. These pumps have 6" intake strainers that may have been improperly soldered during production and, as a result, the strainers may come apart during use, allowing parts of the strainer and debris to enter the pump, possibly damaging the pump.
Hazard: If the strainer and/or debris enters the pump, and the operator is forced to shut down the pump, reducing firefighting effectiveness, there could be an increased risk of injury.
Remedy: Pierce will notify owners to check the strainer for missing solder at the joints. Any strainers missing solder will be replaced, free of charge. The recall is expected to begin in June 2016. Owners may contact Pierce customer service at 1-888-974-3723 or Hale Products Customer Service Center at 1-800-533-3569. Pierce's number for this recall is 74B272.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V390000
   
2016-04-01 (Published by NHTSA on 2016-04-16)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2010-2016 Arrow-XT, Quantum, and Velocity vehicles manufactured from October 30, 2010, through January 24, 2016. The affected vehicles are equipped with Pelican 9410L flashlights, part number 9410-021-245 or 9410-021-110, with lithium ion battery packs which may overheat.
Hazard: If the flashlight battery pack overheats, it can increase the risk of a fire.
Remedy: Pierce will notify owners and instruct them to inspect the flashlight and battery pack, and if necessary, to request a replacement battery pack from Pelican Products, free of charge. The recall is expected to begin on, or about, April 15, 2016. Owners may contact Pierce customer service at 1-414-832-3000. Pierce's recall number for this campaign is 74B271.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V186000
   
2016-03-02 (Published by NHTSA on 2016-03-19)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2016 Arrow-XT, Dash, Enforcer, Impel, Quantum, Saber, and Velocity fire and emergency vehicles manufactured October 13, 2015, to February 9, 2016. The fastener cap over the bearing on the universal joint of the drive shaft may have been improperly tightened.
Hazard: If the cap was not properly tightened, the cap may detach from the vehicle and become a road hazard. Additionally, the universal joint may separate and the vehicle may not be able to be driven, increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will check and correct the tightness of all bolts for the universal joint caps, as needed, free of charge. The recall is expected to begin in March 2016. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B270.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=16V123000
   
2015-10-26 (Published by NHTSA on 2015-11-07)
Recall Summary: Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow XT, Velocity, Enforcer, and Saber vehicles manufactured November 20, 2014, to September 29, 2015. The affected vehicles are equipped with front drive axles whose hex nuts on the flange yoke may not have been properly tightened.
Hazard: If the hex nuts are not tightened to specification, the driveshaft may disconnect from the drive axle, resulting in a loss of propulsion and increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will inspect the hex nuts, tightening them as necessary, free of charge. The recall is expected to begin November 9, 2015. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B266.
Additional Info: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Source: http://www-odi.nhtsa.dot.gov/recalls/recallresults.cfm?start=1&SearchType=QuickSearch&rcl_ID=15V706000
   
Advertisement

Advertisement

Additional Pierce Models

Recalls have also been issued under these model names:

Latest Safety Recalls

Select image for details, including additional styles.

 

Advertisement

Comments

Do you have comments or questions about this recall? Share them here.

Note: The recalling companies may not be monitoring these comments; they should be directed toward the public. Community Guidelines apply.

comments powered by Disqus
Back to Top



Sources may include: National Highway Traffic Safety Administration (NHTSA) and companies involved with this or a related recall.